stupid G20 won't start

[infintig20]

can anyone help me please???

my 91 G20 won't start!! the plugs are ok, distributor, cap and rotor are ok!!! fuel filter changed, battery ok, injectors ok, fuel pump fuse ok,
fuel pump relay ok!!! i'm stuck!!! I took off the feul line leading
to the engine, cranked it and no gas came out so i replaced the fuel filter and tried it again no gas came out, so i checked the relay and fuse
they were both ok!! i'm thinkin the fuel pump is gone!!! anyone
ever have this problem??? i really don't wanna drop the gas tank to
find out the pump is ok and then put it back up!!

thanks,
desperate to get it started

[AznVirus]

have you checked the starter?

[infintig20]

ya the starters fine

[T4 Primera]

Have someone switch the ignition to on (not cranking over) while you listen near the tank for the pump to build pressure. In my car I can hear it from the drivers seat. If no noise, check the harness/plug to the pump is clean and secure.

Yes, I think this has happened to some others on the forum. I think P10DET has had a fuelpump die on him.

[P10DET]

Originally posted by T4 Primera
Yes, I think this has happened to some others on the forum. I think P10DET has had a fuelpump die on him.

Yepper.

If you removed the fuel line and didn't get cover with fuel, I'm pretty certain your pump is gone. The line should be under quite a lot of pressure.

It's not hard to replace, just a little scary. Disconnect the battery (I forgot to - DOH!). Ground the car. Ground yourself if you really want to be safe. You don't want any sparks with the tank open.

BTW, you don't have to drop the tank. The pump is replaced from inside the car. You have to remove the rear seat and you will find an access plate. Just have patience. Took me about an hour to an hour and a half. I could do it in half the time now.

[BuddhaBoy]

Hi guys, I am new to this board and I own a 91 G20. I had the same problem as you which the engine would start for a few second then stutters and dies. I tried changing the battery and checking if it was the alternator but it ended up being the fuel pump causing the problem. Your situation was very similar to mine, so i gotta say it was the fuel pump.

[T4 Primera]

Welcome to AF BhuddaBoy

[frogg]

Originally posted by Everyone
:finger: WELCOME! :finger:

[nis.k.a.]

If it is the fuel pump, like DET said, it's right under your rear seat. It's not like domestic cars where you have to drop the tank, remove gas, and all that other pain in the ass stuff. Good luck with your car.

[RYANS]

it is your fuel pump. same thing hapened to me. had to replace it

[DJ_hoody]

Hi everyone, im having this trouble too, just found this forum , great site btw!!

Im having starting problems, found out when u tap or bang the top of the sender/float unit under the back seats the car starts..bizzare, all i can think is that its either a bad connection or fuel pump is on its way out, i have a spare p10 (g20) at my house for parts, but I havent a clue how to swap them over... p10det can u help plz..
the manual i have doesnt really tell u much...

my car starts sometimes and runs, but sometimes i turn it on and it just stalls then dont work unitl u hit / tap the top of the plastic cap of the float sender unit...

thanx in advance

hoody

[DJ_hoody]

does anyone know how to get the fuel pump out, ive just bee struggling for the last hour, and i cant budge it, now im starting to hallucenate from the fumes..lol